Monk: In honor of Father’s Day, we are reposting our blog from three years ago recapping the first (and thus far only) whole hog I smoked for Father’s Day 2019. Hopefully, I will get to do one again later this year but in the meantime enjoy this trip down memory lane.

Monk: Back on Father’s Day weekend, Speedy and I set out to do something I’ve been wanting to do for years. And you know what? We rocked it. But even using both the Sam Jones: Whole Hog BBQ book and the Buxton Hall Book of Smoke as references, there were still a few speed bumps that we can learn from the next time we smoke another hog (and yes, there will definitely be another time).

Lesson #1 – If your barrel doesn’t have a bottom, don’t set it up on cinder blocks

Monk: The barrel I got, while free, already had both the bottom and top cut off. The top wasn’t needed, but I would have preferred the bottom attached so as to keep the coals in. I did get a tip that an aluminum water heater pan would fit perfectly, and it did. However, after just a couple of hours that pan started to disintegrate so Speedy and I had to figure out a way to get the burn barrel off the cinder blocks mid-burn. We managed to get it done, losing just a few coals in the process. Once we got it on the ground, it was smooth sailing…for at least a little bit.

Speedy: Monk may be underselling this a bit. Taking a hot burn barrel with an active fire off of cinder blocks could’ve ended badly, but the pig was the most important thing. To add to this, I’d say that if placing the barrel on the ground, put a solid sheet of metal that won’t burn through underneath, as it can be difficult shoveling the coals off the ground.

Lesson #2 – Be sure to allow enough time to let a solid bed of coals build up before you start to shovel into the pit

Speedy: What we found was that the cinder block pit we made was losing about 1 degree of temperature a minute, so we ended up dropping coals in every half hour. This shot the temperature back up 30 degrees quickly, but we had trouble keeping enough coals to shovel in (refer to lesson #5).

Monk: We were probably a little bit anxious in adding coals to the pit and should have let the fire go for at least an hour before we started shoveling them in.

Lesson #3 – Get fire proof gloves

Speedy: We were very, very fortunate that Monk’s neighbor had some fireproof grilling gloves that he brought over. These came in VERY handy (refer to Lesson 1), and I wouldn’t try this again without some.

Monk: Yes, these were definitely lifesavers.

Lesson #4 – Get at least a half cord of wood

Monk: In Sam Jones’ book, he says you might be able to get away with a quarter cord of wood, but he recommended at least a half cord because having leftover is far more preferable than running out. In our experience with a half cord, we burned through every last bit of firewood. Next time, I won’t consider ordering anything other than a half cord.

Lesson #5 – And definitely have a few bags of charcoal handy in case its needed (it will be needed)

Speedy: This was something Monk and I didn’t have handy, and we were struggling keeping temperature and weren’t making coals fast enough. Luckily, there was a 24 hour Walmart 10 minutes away, so I went to pick up a couple bags of charcoal while Monk manned the fire. This definitely did the trick, but it would have been nice to have them on-hand.

Lesson #6 – Be sure to have the right thermometer measuring your pit temperature

Monk: I initially used the wrong type of thermometer to measure pit temp (one used for measuring oil used for frying turkeys), and it wasn’t until a couple hours in that we realized we were probably 50 degrees below what we thought we were. Once I plugged in my Maverick Redi-chek thermometer, we were able to adjust our coals accordingly and get the pit temp up to where we needed it to be.

Lesson #7 – Working in shifts is definitely a good idea so that you can get some rest

Monk: We started at midnight to ensure enough time to get the hog done ahead of a 6pm party, and Speedy and I each ended up getting about 4 hours of sleep each. While some late night drinking and BS-ing by the burn barrel is fun and all, make sure you get enough sleep so that you aren’t a zombie the next day at your whole hog party.

Lesson #8 – You will be surprised how quickly the hog gets done

Speedy: Monk had told me the hog would be done in about 12 hours, and I thought no way that could be true. At the end of the day, I think we were cooking around 14 hours, but it definitely could have been done in 12 if we didn’t have temperature issues at the beginning. Lesson learned – never doubt Monk.

Monk: I have nothing else to add here other than to emphasize Speedy’s last point about never doubting me.

Lesson #9 – More is more when it comes to rebar, or consider using a grate

Speedy: To chop the hog, we first split it down the middle and then in quarters at the ribs. Unfortunately, when doing so, one quarter of the hog dropped through the rebar onto the ground. Some of the meat was salvageable, but we probably lost a good 8-10 pounds of meat. The good news is there was still plenty of our 126 pound hog to go around.

Lesson #10 – If you can swing it, smoke your first hog with your best friend

Monk: If Speedy wouldn’t have been able to make it, I would have been doing this solo. Besides the pure labor aspect of smoking a hog, there’s a definite sense of satisfaction of smoking your first hog with a good buddy. And remember – its Barbecue Bros, not Barbecue Bro.